Benone.cz

Page 1 of 5
Thursday, January 24, 2013
MSDS - Material Safety Data Sheet
Product Name: LIQUID WRENCH WHITE LITHIUM GREASE WITH
CERFLON
MSDS No.: L616
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY
Contact: Robert Geer
Address: 600 RADIATOR ROAD
Information Telephone Number: 704-684--181 1
City, ST Zip: INDIAN TRAIL, NC 28079
Emergency Contact: RMPDC (877-740-5015)
Country: USA
Emergency Telephone Number: 303-623-5716
Emergency Restrictions:
Product Name: LIQUID WRENCH WHITE LITHIUM GREASE WITH CERFLON
MSDS No.: L616
Issue Date: 01/24/2013
Supersedes Date: 03/10/2011
II. Hazards Identification:
EMERGENCY OVERVIEW
Danger: Flammable. Harmful or fatal if swallowed. Eye and skin irritant. Contents under pressure.
Level 3 Aerosol
OSHA Regulatory Status
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Potential Health Effects
Route(s) of Entry:
Absorption, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
Signs and Symptoms:
Eye Contact: Irritant. Prolonged contact may cause conjunctivitis.
Skin Contact: Irritant. Defatting of tissue, dermatitis may occur.
Inhalation: Irritant to mucous membranes. Repeated exposure may cause narcosis.
Ingestion: HARMFUL OR FATAL IF SWALLOWED. May cause burns to mouth, throat & stomach.
Medical Conditions Generally Aggravated by Exposure:
Other Health Warnings:
Aspiration of vomitus into the lungs can cause pneumonitis, which can be fatal.
Potential Environmental Effects
III. Composition/Information on Ingredients:
Chemical Name
Trade Secret
Page 2 of 5
Thursday, January 24, 2013
MSDS - Material Safety Data Sheet
Product Name: LIQUID WRENCH WHITE LITHIUM GREASE WITH
CERFLON
MSDS No.: L616
Trimethyl benzene
IV. First Aid Measures:
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical attention.
Skin Contact: Wash with soap and water thoroughly. If adverse effects persist, get prompt medical attention. Launder contaminated clothing
before reuse.
Inhalation: Remove to fresh air. If breathing becomes difficult get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately.
Note to Physicians:
V. Fire Fighting Measures:
Suitable Extinguishing Media:
Water Fog, Foam, Carbon Dioxide, Dry Chemical Unsuitable Extinguishing Media:
Do not use forced water stream as this could cause the fire to spread. Use shield to protect from rupturing and venting containers.
Products of Combustion:
Normal products of combustion, smoke, carbon dioxide, carbon monoxide, and sulfur trioxides.
Protection of Firefighters:
Wear self-contained positive pressure breathing apparatus and protective clothes. Use shield to protect from rupturing and venting containers. At elevated temperatures containers may vent, rupture or burst, even violently VI. Accidental Release Measures:
Personal Precautions:
Persons not wearing protective equipment should be excluded from area of spill until clean-up has been completed.
Environmental Precautions:
Prevent run-off to sewers, streams, or other bodies of water. If run-off occurs, notify proper authorities as required that a spill has occurred. Run
off to sewer may create fire or explosion hazard.
Methods for Containment:
Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags, etc).
Methods for Cleanup:
Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where possible, vacuum spilled liquid using
an explosion proof vacuum to recover material.
Other Information:
If run-off occurs, notify proper authorities as required that a spill has occurred.
VII. Handling and Storage:
Handling Precautions:
Use with adequate ventilation and proper protective equipment.
Do not use or store near fire, sparks, or open flame. Do not puncture or incinerate container.
Storage Precautions:
Store in cool, well ventilated area below 120°F away from heat, fire, sparks or flame. Exposure to temperatures above 120° may cause container to vent, rupture, or burst. Do not store with strong oxidizing agents VIII. Exposure Controls/Personal Protection:
Page 3 of 5
Thursday, January 24, 2013
MSDS - Material Safety Data Sheet
Product Name: LIQUID WRENCH WHITE LITHIUM GREASE WITH
CERFLON
MSDS No.: L616
Chemical Name
ACGIH TLV
Other Limits
Engineering Controls:
See above for applicable exposure limits. Maintain adequate ventilation.
Avoid breathing vapors. In restricted areas, use approved chemical filters designed to remove vapor. In confined areas, use approved air line type
respirator or hood. A self-contained breathing apparatus is required for vapor concentrations above TLV limits.
Personal Protective Equipment:
For prolonged exposure wear protective safety glasses, gloves, and apron.
IX. Physical and Chemical Properties:
Boiling Point: 320°F
Melting Point: N/A
Boiling Range: N/D
Freezing Point: N/D
Solubility In Water: Insoluble
Evaporation Rate (Butyl Acetate = 1): N/D
Flash Point: 104°F
Flash Point Method: TCC
Odor Threshold: N/D
Appearance and Odor: Opaque dense off white suspension with
Vapor Density (AIR = 1): N/D
Vapor Pressure (mm Hg.): N/D
pH Range: N/A
Partition Coefficient: N/D
Decomposition Temp: N/D
Auto-Ignition Temp: N/D
Lower Explosive Limit: 0.7%
Upper Explosive Limit: 7.0%
Specific Gravity (H20 = 1): 0.80
Other Information: VOC Content: 49%
X. Stability and Reactivity:
Stability:
Stable
Conditions to Avoid:
N/D
Incompatible Materials:
Avoid strong oxidizers.
Hazardous Decomposition Products:
Normal products of combustion, smoke, carbon dioxide, carbon monoxide, and sulfur trioxides.
Possibility of Hazardous Reactions:
Will not occur
Page 4 of 5
Thursday, January 24, 2013
MSDS - Material Safety Data Sheet
Product Name: LIQUID WRENCH WHITE LITHIUM GREASE WITH
CERFLON
MSDS No.: L616
XI. Toxicological Information:
XII. Ecological Information:
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in aerosol recycling centers when empty. Before offering for recycling, empty the can by using the product according to the label. DO NOT PUNCTURE! If recycling is not available, wrap the container and discard in the trash. Dispose of unused product in accordance with all local, state government and federal laws and regulations.
XIV. Transport Information:
Shipping Name: Consumer Commodity
DOT Hazard Class: ORM-D
DOT Subsidiary Hazard Class: Not Available
UN/NA#: Not Available
Packing Group:
Transportation Information:
DOT Hazard Class: ORM-D
Shipping Name: Consumer Commodity
The DOT description is provided to assist in the proper shipping classification of this product and may not be suitable for international and air shipping purposes.
ICAO/IATA (US)Shipping Name: AerosolsClass: 2.1UN number: UN1950 ICAO/IATA UN number: UN1950Shipping Name: AerosolsClass: 2.1 IMDGUN number: UN1950Shipping Name: AerosolsClass: 2.1EmS: F-D, S-U XV. Regulatory Information:
Page 5 of 5
Thursday, January 24, 2013
MSDS - Material Safety Data Sheet
Product Name: LIQUID WRENCH WHITE LITHIUM GREASE WITH
CERFLON
MSDS No.: L616
SARA 313 Chemicals:
1,2,4-Trimethylbenzene 95-63-6
Isopropylbenzene 98-82-8
Naphthalene 91-20-3
Ethylbenzene 100-41-4
USA TSCA: All components of this material are listed on the US TSCA Inventory.
PROPOSITION 65 WARNING: This product product contains a chemical known to the State of California to cause cancer, birth defects and other reproductive harm.
State RTK Chemicals:Aliphatic Hydrocarbon 8052-41-31,2,4-Trimethylbenzene 95-63-6sopropylbenzene 98-82-8Naphthalene 91-20-3 Ethylbenzene 100-41-4Trimethylbenzene 25551-13-7 XVI. Other Information:
Chemical State:
Chemical Type:
Hazard Category:
Additional Manufacturer Warnings:
Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye. KEEP AWAY FROM CHILDREN AND ANIMALS! N/A: Not Applicable
N/AV: Not Available
Additional Product Information:
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the data and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.

Source: http://www.benone.cz/file/p633.pdf